T/CCMA 0192-2024高原隧道純電動輪胎式裝載機

ICS53.100

CCSP97

團體標準

T/CCMA0192—2024

高原隧道純電動輪胎式裝載機

Batteryelectricwheelloaderforplateautunnels

2024?06?28發布2024?07?01實施

中國工程機械工業協會發布

中國標準出版社出版

T/CCMA0192—2024

目次

前言··························································································································Ⅲ

1范圍·······················································································································1

2規范性引用文件········································································································1

3術語和定義··············································································································3

4型號編制規則及參數··································································································4

5要求·······················································································································5

6試驗方法···············································································································12

7檢驗規則···············································································································19

8標志、包裝、運輸和貯存·····························································································22

附錄A（資料性）裝載機基本參數··················································································24

附錄B（規范性）裝載機作業性能試驗············································································26

附錄C（資料性）海拔修正系數·····················································································29

Ⅰ

T/CCMA0192—2024

前言

本文件按照GB/T1.1—2020《標準化工作導則第1部分：標準化文件的結構和起草規則》的規

定起草。

請注意本文件的某些內容可能涉及專利。本文件的發布機構不承擔識別專利的責任。

本文件由中國工程機械工業協會提出并歸口。

本文件由中國工程機械工業協會雙碳標準化技術委員會、中國工程機械工業協會雙碳工作委員會

組織制定。

本文件起草單位：廣西柳工機械股份有限公司、徐工集團工程機械股份有限公司科技分公司、山推

工程機械股份有限公司、中鐵四局集團第四工程有限公司、中國工程機械工業協會雙碳工作委員會、

中機科（北京）車輛檢測工程研究院有限公司、川藏鐵路技術創新中心有限公司、雷沃重工集團有限公

司、深圳市比亞迪鋰電池有限公司、寧德時代新能源科技股份有限公司、中鐵長安重工有限公司、中國

鐵道科學研究院集團有限公司、太原科技大學。

本文件主要起草人：朱泉明、郭文明、陳鵬、汪冰、邸鵬遠、黃海潮、郭春華、王正航、李冰天、歐陽湘龍、

司發庫、高博、高紅杰、要志斌、范曉蘭、王濤、李志芳、王兆亮、王志偉。

Ⅲ

T/CCMA0192—2024

高原隧道純電動輪胎式裝載機

1范圍

本文件界定了高原隧道純電動輪胎式裝載機（以下簡稱“裝載機”）的術語和定義，給出了型號編制

規則及參數，規定了技術要求、標志、包裝、運輸和貯存等方面的內容，描述了相應的試驗方法，確立了

檢驗規則。

本文件適用于高原環境隧道工況使用的以機載可充換電儲能系統（最大工作電壓為B級電壓）作

為唯一動力源的裝載機。

本文件不適用于在爆炸性環境作業的裝載機。

2規范性引用文件

下列文件中的內容通過文中的規范性引用而構成本文件必不可少的條款。其中，注日期的引用文

件，僅該日期對應的版本適用于本文件；不注日期的引用文件，其最新版本（包括所有的修改單）適用于

本文件。

GB/T4208—2017外殼防護等級（IP代碼）

GB/T5182叉車貨叉技術要求和試驗方法

GB/T8419—2023土方機械司機座椅振動的試驗室評價

GB/T8498土方機械基本類型識別、術語和定義

GB/T8593.1土方機械司機操縱裝置和其他顯示裝置用符號第1部分：通用符號

GB/T8593.2土方機械司機操縱裝置和其他顯示裝置用符號第2部分：機器、工作裝置和附

件的特殊符號

GB/T8595土方機械司機的操縱裝置

GB/T10175.1—2008土方機械裝載機和挖掘裝載機第1部分：額定工作載荷的計算和驗證

傾翻載荷計算值的測試方法

GB/T14039—2002液壓傳動油液固體顆粒污染等級代號

GB/T14048.1—2023低壓開關設備和控制設備第1部分：總則

GB/T14685—2022建設用卵石、碎石

GB/T14711中小型旋轉電機通用安全要求

GB/T14781—2023土方機械輪式機器轉向要求

GB/T16935.1—2023低壓系統內設備的絕緣配合第1部分：原理、要求和試驗

GB/T16937土方機械司機視野試驗方法和性能準則

GB/T17300土方機械通道裝置

GB/T17301土方機械操作和維修空間棱角倒鈍

GB/T17771—2010土方機械落物保護結構試驗室試驗和性能要求

GB/T17921—2010土方機械座椅安全帶及其固定器性能要求和試驗